2015 Toyota Sienna

NHTSA campaign 19V553000 · 303 vehicles

Problem

Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.

Risk

The contact may cause failure of the rear brake hoses, resulting in a loss of vehicle control and reduced braking ability, increasing the risk of a crash.

Fix

Vantage will notify owners, and dealers will install a set of rear brake hoses that will provide the proper clearance, free of charge. The recall began December 16, 2019. Owners may contact Vantage customer service at 1-800-488-9082.

NHTSA campaign 19V410000 · 705 vehicles

Problem

Braun Corporation (Braun) is recalling certain 2014-2019 Toyota Sienna mobility van conversions. The brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system.

Risk

The reduction in the braking system pressure may cause a loss of braking power in the rear braking system, increasing the risk of crash.

Fix

Braun has notified owners, and dealers will install an adaptor to correct the issue, free of charge. The recall began June 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.

NHTSA campaign 16V858000 · 744,437 vehicles

Problem

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.

Risk

If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.

Fix

Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G04.

NHTSA campaign 15V240000 · 387 vehicles

Problem

Gulf States Toyota, Inc. (GST) is recalling certain model year 2015 Toyota Sienna vehicles manufactured January 23, 2015, to April 13, 2015, and equipped with non-Toyota-brand overhead entertainment accessories installed by GST. During reassembly of the interior after the overhead entertainment system installation, a trim panel securing clip may have been reused instead of being replaced.

Risk

If the clip was damaged during the entertainment system installation, in the event of a side curtain air bag deployment, the trim panel may detach and strike one of the vehicle occupants, increasing the risk of injury.

Fix

GST will notify owners, and dealers will replace the trim panel securing clip, free of charge. The recall began June 5, 2015. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 15R1.

NHTSA campaign 15V236000 · 262 vehicles

Problem

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2015 Sienna vehicles manufactured September 1, 2014, to April 13, 2015 and equipped with overhead entertainment accessories installed by SET. During reassembly of the interior after the overhead entertainment system installation, a trim panel securing clip may have been reused instead of being replaced.

Risk

If the clip was damaged during the entertainment system installation, in the event of a side curtain air bag deployment, the trim panel may detach and strike one of the vehicle occupants, increasing the risk of injury.

Fix

SET will notify owners, and dealers will replace the trim panel securing clip, free of charge. The recall began on May 22, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET15B.

NHTSA campaign 14V757000 · 25,551 vehicles

Problem

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Sienna vehicles manufactured September 2, 2014, to November 25, 2014. In the event of a crash that necessitates the deployment of the curtain shield airbag (CSA), the second row overhead assist grips may detach.

Risk

If the assist grip detaches due to CSA deployment, the grip may strike a vehicle occupant, increasing the risk of injury.

Fix

Toyota will notify owners, and dealers will modify the headliner near the second row overhead assist grip, free of charge. The recall began on January 15, 2015. Owners may contact Toyota customer service at 1-800-331-4331.