Ford Bronco Sport 2023

Campaña NHTSA 26V340000 · 4,653 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.

Riesgo

A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.

Solución

Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.

Campaña NHTSA 25V685000 · 59,006 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Riesgo

An electrical short circuit can increase the risk of a fire.

Solución

Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated December 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Campaña NHTSA 25V467000 · 694,271 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Riesgo

A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.

Solución

Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.

Campaña NHTSA 25V442000 · 200,237 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Riesgo

A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Solución

Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

Campaña NHTSA 25V158000 · 48,041 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Riesgo

An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

Solución

Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.

Campaña NHTSA 25V165000 · 33,576 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.

Riesgo

A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Solución

Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.

Campaña NHTSA 25V019000 · 272,817 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.

Riesgo

Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.

Solución

Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.

Campaña NHTSA 24V594000 · 86,852 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.

Riesgo

Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.

Solución

Dealers will inspect and replace the windshield wiper motor as necessary, free of charge. Owner notification letters were mailed on December 6, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S51.

Campaña NHTSA 24V267000 · 456,565 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Riesgo

An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

Solución

Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.

Campaña NHTSA 24V223000 · 115 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2023 Maverick and Bronco Sport vehicles. The tires may have been manufactured incorrectly, which may result in a loss of vehicle handling and control.

Riesgo

A loss of vehicle handling and control increases the risk of a crash.

Solución

Dealers will inspect and replace the tires, as necessary, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S20.

Campaña NHTSA 24V187000 · 42,652 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Riesgo

A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Solución

Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Owner notification letters were mailed on April 24, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S16. This recall is an expansion of previous recall number 22V-859.

Campaña NHTSA 23V021000 · 801 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2023 Bronco Sport vehicles. Valves inside the Anti-lock Brake System (ABS) module may have been damaged during manufacturing, causing an internal ABS module leak.

Riesgo

A leak inside the ABS module can cause an unexpected increase in brake pedal travel or unexpected movement during an Auto Hold event, increasing the risk of a crash.

Solución

Dealers will replace the ABS Module, free of charge. Owner notification letters were mailed on May 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S01.

Campaña NHTSA 22V859000 · 521,746 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Riesgo

A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Solución

Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.

Campaña NHTSA 22V686000 · 86,050 vehículos

Problema

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Riesgo

Flickering parking lights can reduce visibility, increasing the risk of a crash.

Solución

Dealers will replace the LED Driver module, free of charge. Owner notification letters were mailed March 29, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C22.